* LEAVE FOR HOMEOWNERNOTE: Due to ongoing research and product development, specifications, ratings and dimensions are subject to change without n
Water Heater ThermostatThe water heater thermostat is set by theinstalling contractor to provide the required temperature at the hot water outlet of t
temperature is approx. 130˚F (54˚C) which is60˚F (15.5˚C) above the return air temperature.These units typically have a temperature rise of35˚F (2˚C)
12Model ConfigurationCAF - Clean Air Furnace(Built-in HRV)AH - Air Handler(No HRV) ConfigurationU - UpflowD - DownflowH - HorizontalHydronic Coil Siz
13Model CAF-U-S4A-24-P16Voltage 120 VAC 60 HzHp 1/3Amps (total) 7Water1/2" Copper SolderedConnections ConnectionAirflow (High).25 in wg 1030 CFM.
14Options99-186 Weatherhoods, Two - 6" c/w1/4" mesh screen99-130W Remote Wall Mount DehumidistatControl 24 VAC only99-RSK6 6” back draft dam
15Options99-186 Weatherhoods, Two - 6" c/w1/4" mesh screen99-130W Remote Wall Mount DehumidistatControl 24 VAC only99-RSK6 6” back draft dam
16Options99-186 Weatherhoods, Two - 6" c/w1/4" mesh screen99-130W Remote Wall Mount DehumidistatControl 24 VAC only99-RSK6 6” back draft dam
Front19"47.5"LatchesBlower Section (SERVICE CLEARANCE 10")Top29.5"6"6"14"12"4"VentilationSupplyAir InletV
Front19"47.5"LatchesBlower Section (SERVICE CLEARANCE 10")Side29.5"6"6"14"12"4"VentilationSupplyAir Inlet
19Options99-186 Weatherhoods, Two - 6" c/w1/4" mesh screen99-130W Remote Wall Mount DehumidistatControl 24 VAC only99-RSK6 6” back draft dam
2Table of ContentsIntroduction ... 3Descripti
20Options99-186 Weatherhoods, Two - 6" c/w1/4" mesh screen99-130W Remote Wall Mount DehumidistatControl 24 VAC only99-RSK6 6” back draft dam
21TopSide29.5"29.5"19"47.5"6"6"14"12"4"19"22.25"Supply Air17.25"VentilationSupply AirInlet
The purpose of this manual is to give the contractorguidelines for installing the LIFEBREATH Clean AirFurnace. All national and local codes relating t
Penetrations from sheet metal screws used tofasten the ductwork to the cabinet of the unitshould only be placed into the duct flange provided.This is
Locating Intake WeatherhoodThe intake weatherhood should be locatedas follows:• 4 - 6' from ventilation exhaust hood, and upstream of prevailing
It is necessary to have balanced air flows in anHRV. The volume of air brought in from the outsidemust equal the volume of air exhausted by the unit.I
This is an example for determining the airflow in a6" duct. The Pitot tube reading was 0.025inches of water. From the chart, this is 640 feet per
Drain LineThe ventilation portion of the Clean Air Furnacehas two drain pans for removing condensation,which may occur on the heat recovery core durin
28WaterHeaterCheckValveTo HouseCAForAHMin. 12" above top of CAF / AH12"WaterHeaterCAForAHCheckValveMin. 12" above top of CAF / AHTo Hou
29LD1T30 T31POOLSW1FDDDheatcoolDFR2T32 T33 T34 T35 T36 T37 T38 T39 T40 T41 T42T29Contact 1N.0. COM N.C. N.0. COM N.C. N.0. COM N.C. N.0 . COM
3IntroductionCongratulations on your selection of the LIFEBREATH Clean Air Furnace (CAF). This is a very advanced unitthat combines the outstanding ef
30Switch SettingAdjust SwitchesBoth OFF5 0N - 6 OFF5 OFF - 6 ON5 ON - 6 ONHeatNormalIncrease 15%Decrease 15%NormalCoolNormalIncrease 15%Decrease 15%No
31OperationHeating/CoolingWhen the room thermostat calls for heat, it acti-vates a circulation pump located inside the CleanAir Furnace. This pump del
32Start-Up ProcedureIn order for any appliance to work properly it mustbe set up and tested by a knowledgeable technician.The following conditions mus
33Lack of heat1. Check that the room thermostat is set to thedesired temperature.2. Confirm the units have power and the shut-offvalves are open.3. En
34Humidity levels are too low1. If you have installed a dehumidistat ensure thatits setting is correct. (Summer - OFF) (Winter -30% RH to 45% RH).2. C
35Water Pump Performance Specifications1614121086420 Capacity on U.S. gpmS2 and S4 Models1 2 4
4Description and PurposeIMPORTANT NOTEThe purpose of this manual is to act as an instal-lation guide only for the LIFEBREATH Clean AirFurnace. Manufac
41
42CAF/Air Handler Wiring Diagram60-CAF-AH-010803REDWHITEBLUEBLACKTHERMISTORTO A/C CONDENSERPumpFanMotorLD1T30 T31POOLSW1FDDDheatcoolDFR2T32 T33 T34 T3
43Transformer12/24VacECM - CAF/Air Handler Wiring DiagramPumpLD1T30 T31POOLSW1FDDDheatcoolDFR2T32 T33 T34 T35 T36 T37 T38 T39 T40 T41 T42T29Contact 1N
Closed/Open Combo SystemFrom the aspect of delivery of domestic hotwater and space heating, the Open and Closedsystems operate the same. A system beco
Call for Space Heating OnlyOperationWhen the thermostat calls for heat, the circulation pump is activated and hot water isdrawn from the top of the wa
Manual ValvesThere are a number of manual valves required forthe system to operate properly and safely. Thesevalves are used as shut off valves, drain
Shut Off ValvesThere are 3 shut off valves required for an integrated combo system as follows:• One valve (a) on the cold water side of the water heat
Expansion TanksExpansion tanks are required for “ClosedSystems”(most municipal water systems areclosed systems). The expansion tank has an air bladder
Comments to this Manuals